kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 03:02 PM
I might be ordering a 5lb spring then.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
  
|
1badzx12r
Needs a life
Posts: 8321
|
posted September 05, 2012 03:08 PM
quote:
You are correct, it is a journal bearing. Dont know why I got ball bearing in my head. It doesnt have a water cooled center housing, duh! If I'm reading the box right, looks to be 49 trim.
i told you that was a cheap ass turbo .. all that polish is the eye catcher
____________
http://www.youtube.com/watch?v=S06nIz4scvI
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 03:18 PM
quote:
quote:
You are correct, it is a journal bearing. Dont know why I got ball bearing in my head. It doesnt have a water cooled center housing, duh! If I'm reading the box right, looks to be 49 trim.
i told you that was a cheap ass turbo .. all that polish is the eye catcher
Not a cheap ass turbo you Goober smoocher.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
Slow14_Fz1
Novice Class
Posts: 83
|
posted September 05, 2012 03:23 PM
Summit racing has them for $26.99 part# TBS-TS-0505-2002
____________
08 zx14 Turbo 17lbs 8.84@159 spinning
2012 zx14r NA 5.93@118 9.30@147 best 1.37 60'
|
Slow14_Fz1
Novice Class
Posts: 83
|
posted September 05, 2012 03:26 PM
I would order a gt30r BB with the .63 A/R and call it a day.
____________
08 zx14 Turbo 17lbs 8.84@159 spinning
2012 zx14r NA 5.93@118 9.30@147 best 1.37 60'
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 03:27 PM
quote:
Summit racing has them for $26.99 part# TBS-TS-0505-2002
You read my mind. Muzzys and I have had a discussion last week about this gate spring thing. There's more but that is a later discussion.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 03:30 PM
quote:
I would order a gt30r BB with the .63 A/R and call it a day.
I aint that serious. We are gonna make do.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
ZX14MAN
Parking Attendant
Posts: 18
|
posted September 05, 2012 03:31 PM
Sure looks like alot of money and ambition involved.
Good luck with it. LooI bet its gonna be as a monster.
|
Slow14_Fz1
Novice Class
Posts: 83
|
posted September 05, 2012 03:42 PM
I would also put a BOV on the left side ram air cover to prevent compressor surge.
____________
08 zx14 Turbo 17lbs 8.84@159 spinning
2012 zx14r NA 5.93@118 9.30@147 best 1.37 60'
|
codyc_13
Expert Class
Posts: 342
|
posted September 05, 2012 04:07 PM
James, Hows the progress coming? I want to see that thing on the track!!!
____________
06 zx14, 65", lowered, muzzy pipe, pcIII, air shifter, Litz revalve, Adams cut seat, OSR cut pan 87 pump gas.
8.97 at 149mph
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 05:12 PM
quote:
James, Hows the progress coming? I want to see that thing on the track!!!
It's coming along good. I may have a week or two left on it. Waiting on an oil hose this week before I can finish it anyway.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 05:39 PM
Epoxied the steering tube hole and to silicone the velocity stack seals because of the leaks. Taped up the inlet of the stacks to pressure test which I found unnecessary after the fact because the valves just so happened to be closed. Pressured it up to 8-9 psi and it held with my finger over the hole( I know the pic shows 6psi). Very happy with that.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 05:48 PM
Finished wiring the scavenge and fuel pump relays with circuit breaker and fuses to the batt. box cover. Don't want to shorten any wires just yet so they will stay rolled up for a bit. Poured a little fuel fuel in the tank and ran the fuel pump to set a ball park baseline of 45psi. Pressured up the airbox to 6 psi and set the FMU needle valve to 80 psi. Probably should go up to 90psi. I know this will not be the case as the engine is using fuel because the pressure will drop considerably. The pump shows 100+ psi on the guage if the needle is turned in.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
Wheelie
Needs a life
Old Man
Posts: 6902
|
posted September 05, 2012 05:57 PM
Coming along nicely James.
wee
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 06:14 PM
I got a weird issue now. The "FI" warning comes on when I pressure the airbox with the key on. Let off the pressure the warning goes off. Does not do it every time though, just intermittently. I did put a vacuum check valve in the map sensor line. Maybe the check valve is not seating in time?? Thoughts please.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
Meangreen14
Expert Class
Posts: 343
|
posted September 05, 2012 06:35 PM
Did you take out the sensor on the top left air box plate?
____________
PCV, quick shifter, stock gearing,
fly's out, custom garrett gt28 stage1 turbo, JE pistons, 625cc inj, MTC lock up clutch,1:1 fuel pressure regulator...
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 06:40 PM
quote:
Did you take out the sensor on the top left air box plate?
No, that is the air temp probe.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
kawasakijockey
Pro
Posts: 1876
|
posted September 05, 2012 07:39 PM
quote:
I got a weird issue now. The "FI" warning comes on when I pressure the airbox with the key on. Let off the pressure the warning goes off. Does not do it every time though, just intermittently. I did put a vacuum check valve in the map sensor line. Maybe the check valve is not seating in time?? Thoughts please.
I figured out I gotta put a bleed check valve in there..No biggie.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
kawasakijockey
Pro
Posts: 1876
|
posted September 08, 2012 03:52 PM
She runs! Got some other little things to do but can't get to the dyno until the 5lb wastegate spring arrives here next week.
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
codyc_13
Expert Class
Posts: 342
|
posted September 08, 2012 03:58 PM
Awesome!!!
____________
06 zx14, 65", lowered, muzzy pipe, pcIII, air shifter, Litz revalve, Adams cut seat, OSR cut pan 87 pump gas.
8.97 at 149mph
|
cas15
Expert Class
Posts: 331
|
posted September 08, 2012 05:04 PM
dam u put it together quick nice work
|
kawasakijockey
Pro
Posts: 1876
|
posted September 08, 2012 05:13 PM
quote:
dam u put it together quick nice work
I always got an "F" in recess..because I don't play..lol
____________
Get on the shortbus boys 'cause its time to get schooled.
2007 ZX-14
1.38 60ft
9.03 @ 149mph
8.95 @153 small shot n2o
8.68 @160mph 5lbs boost
|
Quarter Pounder
Pro
with Cheese
Posts: 1069
|
posted September 08, 2012 05:30 PM
Right on James!!! Good work! Can't wait to see how it dyno's.
____________
SWB 2008 ZX-14
9.19 @ 151
5.98 @ 123
1.53 60'
|
KZScott
Needs a life
high on speed
Posts: 7235
|
posted September 08, 2012 06:55 PM
cool, keep it coming
____________
01 ZX-12R 8.84 @ 156.3 no bars, DOT tires. Pump Gas, NA.... turbo 8.47 @ 164.
00 ZX-12R 8.62 @ 165.2 no bars, slicks, Pump Gas, 55 shot.... turbo 8.32 @173
00 ZX-12R Fastest NA Kawasaki in the world 1: 222.046 1.5: 226.390 Loring AFB
00 ZX-12R street turbo 1: 227.9 1.5: 234.1 Loring AFB
00 ZX-12R LSR turbo 1: 263.1 1.5: 266.5 Loring AFB Worlds fastest ZX-12R
CMG Racing RCC Turbos
|
1badzx14
Expert Class
08 Turbo zx14!!!
Posts: 133
|
posted September 10, 2012 05:38 AM
Yep.....i love riding my boosted foeteen!!!!!!
|
|
|
HOME
NEW TOPIC